Please%20understand%20your%20entire%20HWH%20Operator

1
Please understand your entire HWH Operators
Manual BEFORE operating your Leveling System.
Instructions may vary slightly from coach to
coach. Read CAUTIONS and PROCEDURES carefully.
IMPORTANT
2

LEVELING PROCEDURES Computerized Leveling
System FEATURING Straight-Acting Jacks and
Suspension Dump
HWH 625 SINGLE STEP
3
AUTO LEVEL
With the vehicle parked, the park brake set and
the vehicle ignition in the ACC position
4
AUTO LEVEL
No more than two level low indicator lights may
be on.
5
AUTO LEVEL
For this scenario, we will leave the RIGHT
SIDE and FRONT END level low lights on.
6
AUTO LEVEL
Press and release the AUTO LEVEL button one
time the Auto Level light will begin flashing.
7
AUTO LEVEL
For approximately 25 seconds air will be dumped
from the vehicle suspension.
8
AUTO LEVEL
With the suspension dumped, the system will look
for yellow lights.
9
AUTO LEVEL
A SIDE light will be recognized before a FRONT or
REAR light.
10
AUTO LEVEL
This yellow light indicates that the right side
of the vehicle is low.
11
AUTO LEVEL
The right side jacks will extend. As the jacks
extend their (red) WARNING lights will come on.
12
AUTO LEVEL
The TRAVEL MODE light will go out when any jack
WARNING light comes on.
13
AUTO LEVEL
The right side jacks will continue to extend
until the right side yellow light goes out.
14
AUTO LEVEL
In this scenario the front yellow light is still
on.
15
AUTO LEVEL
Both front jacks will extend to raise the front
of the vehicle. The left front jacks (red)
WARNING light will come on.
16
AUTO LEVEL
As the front jacks extend the front of
the vehicle will raise and the front yellow light
will go out.
17
STABILIZE
With no yellow lights on, the vehicle is
level. The system will now stabilize the vehicle
by extending any remaining jacks.
18
STABILIZE
In this scenario the left rear jack will
extend. Its (red) WARNING light will come on.
19
STABILIZE
The jack will continue to extend until it
is seated firmly on the ground.
20
STABILIZE
With the vehicle level and stabile the
system will shut down.
21
(No Transcript)
22
MANUAL OPERATIONS
23
MANUAL LEVEL
With the vehicle parked, the park brake set and
the vehicle ignition in the Accessory
position, the TRAVEL MODE light will be on.
24
MANUAL LEVEL
Press and hold the MANUAL DUMP button until all
air is exhausted from the suspension system.
25
MANUAL LEVEL
No more than two level low indicator lights may
be on.
26
MANUAL LEVEL
For this scenario, we will leave the LEFT
SIDE and FRONT END level low lights on.
27
MANUAL LEVEL
Press and hold the UP ARROW closest to the side
(yellow) light that is on.
28
MANUAL LEVEL
As you hold the UP ARROW the left side jacks
will extend. As the jacks extend their (red)
WARNING lights will come on.
29
MANUAL LEVEL
Release the UP ARROW when the left side yellow
light goes out.
30
MANUAL LEVEL
In this scenario the front yellow light is still
on.
31
MANUAL LEVEL
Press and hold the UP ARROW closest to the front
(yellow) light.
32
MANUAL LEVEL
Both front jacks will extend to raise the front
of the vehicle. The right front jacks (red)
WARNING light will come on.
33
MANUAL LEVEL
As the front jacks extend the front of
the vehicle will raise. Release the UP ARROW
when the front end yellow light goes out.
34
MANUAL LEVEL
With no yellow lights on, the vehicle is
level. Stabilize the vehicle by extending
any remaining jacks.
35
STABILIZE
Press and hold the UP ARROW closest to the rear
of the coach symbol.
36
STABILIZE
The right rear jacks (red) WARNING light will
come on.
37
STABILIZE
Release the button when the right rear jack has
reached the ground and slightly lifted the
vehicle.
38
STABILIZE
With the vehicle level and stabile turning
the vehicle ignition key to OFF will turn
the touch panel off.
39
FINISHED